• Thank you for visiting HeavyEquipmentForums.com! Our objective is to provide industry professionals a place to gather to exchange questions, answers and ideas. We welcome you to register using the "Register" icon at the top of the page. We'd appreciate any help you can offer in spreading the word of our new site. The more members that join, the bigger resource for all to enjoy. Thank you!

Recent content by Millworks

  1. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    Radiator Fan (questionable): I believe the fan may be the issue (and/or associated controllers/sensors). I purchased a digital temperature this morning to do another test run and check temps, but didn't get far enough to take temps. The fan is now engaging immediately upon cold start (on low)...
  2. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    RUN RESULTS: All seemed to be good ... unfortunately ended with auto shut-down. I've attached a photo of the digital display: 1.) the icon on the righthand side of the hours was flashing, while the spanner icon was solid 2.) the above applies to both when running as well as post shut-down At...
  3. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    Ha ... I'm way past the point of being overwhelmed ..., but that's to be expected with "steep learning curve(s) for the mechanically challenged" such as myself ... so all good. I'l go and give it a tester now. And yes I'm using a red coolant compliant with the VW spec (concentrate plus...
  4. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    I was referring to the sensor next to the thermostat? Could I still be looking at a blockage somewhere. I'm guessing that the functionality of the auxiliary pump would have no bearing on it? Should I just fill and test run with the new coolant and maybe I had an air pocket last test? Cheers
  5. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

  6. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    I finally replaced the thermostat (and housing). The old one looked to be in good condition at first glance. However it was about 5 times hard to depress the spring valve than the new replacement. I'm guessing that means it was cactus? I've only just now let it run up to temperature while...
  7. M

    Linde H25T Series 392 (DOM:2004) VW LPG - Hydraulic Problem

    No probs ... I really appreciate any and all pointers so I'll always post the results. Unfortunately, for the past week I've been pre-occupied (going sideways) attempting to resolve the overheating issues on my other Linde (H45T). Thanks again
  8. M

    Linde H25T Series 392 (DOM:2004) VW LPG - Hydraulic Problem

    Thank you very much ... I'll do as instructed. Cheers
  9. M

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem

    Linde H45T 394 Series (VW LPG) Overheating, Cooling System Problem Hi, I have a Linde H45T which overheats and shuts-down after 10-15 minutes. At which time coolant overflow it evident. I presume this is due to the coolant overheating? ... I should point out that I'm somewhat mechanically...
  10. M

    Linde H25T Series 392 (DOM:2004) VW LPG - Hydraulic Problem

    Hi, I have a Linde H25T with failing hydraulics. I have just carried out the following: 1.) Side-shift hydraulic cylinder - new seals (works fine) 2.) Joystick (1 of 2) right-hand side... side-shift control (works fine) Lifts and tilts, but doesn't hold. The tilt is the worst as all hydraulic...
See more
Top